Search results

  1. S

    W639 Vito MAF fault P0101 / P010106

    From what I can see on other Mercedes diesels the Boost pressure downstream of low-pressure turbocharger reading is indeed around 1 bar normally. I cannot find this sensor tho, anybody know where it is?
  2. S

    W639 Vito MAF fault P0101 / P010106

    So I've have had a look at the sensor values, nothing seems out of the ordinary to me except 1... Boost pressure downstream of low-pressure turbocharger 0.06 Bar Is this a sensor that is used? If so I would expect it to read 1 bar like the rest with the engine off. All values with engine off...
  3. S

    W639 Vito MAF fault P0101 / P010106

    I'll take another look at the sensor values. I rigged up a compressor to the intake hose and pressurized it to 0.5 bar and couldn't hear any leaks. Tool about 5 seconds for the pressure to drop to zero but my improvised blanks were leaking a little. I presume a leak large enough to cause this...
  4. S

    W639 Vito MAF fault P0101 / P010106

    Checked the two intercooler hoses, the turbo side had a internal seal that looks a bit flat but no holes. Stuck some ptfe tape round it to pad it out until I get a new pipe. Inlet manifold pipe and seals look ok. Can't get the code to clear even with the engine off, any ideas?
  5. S

    W639 Vito MAF fault P0101 / P010106

    I've got a 2012 W639 Vito 113 on approx 200k, which earlier this week decided to go into limp mode. I've checked the codes with my Icarsoft MB2.0 and got the following codes: P0101 Mass or Volume air flow sensor A circuit range / performance P010106 Mass air flow sensor 1 has a malfunction...
  6. S

    Vito W639 showing "ESP visit workshop"

    Just in case anyone else finds this useful.... So found the fault in the end, turned out to be the brake light switch! A common fault I know but I thought I had ruled it out but checking the brake lights and watching it operate on my icarsoft. Turns out the brake light switch has 2 pairs of...
  7. S

    Vito W639 showing "ESP visit workshop"

    Thanks for letting me know. Logically you would have thought the ABS sensor would have brought up an ABS fault, clearly not though. Might have to revisit my wheel speed sensors a bit more thoroughly.
  8. S

    Vito W639 showing "ESP visit workshop"

    I have checked the rear wheel speed sensors now on resistance and like the front they both measure the same. I was unable to rotate the wheel and check the AC millivolts as i was doing it on my own. If a wheel speed sensor was faulty, logically I would expect an ABS fault? I have not taken...
  9. S

    Vito W639 showing "ESP visit workshop"

    I have checked both front wheel speed sensors with a multimeter and their loop is 5M ohms each, I'm assuming this is fine as they are both the same. I have managed to successfully complete the steering angle sensor calibration using the iCarsoft and now the ABS fault has gone away, in fact...
  10. S

    Vito W639 showing "ESP visit workshop"

    It's had new tyres all round 1000 Mike's ago, I will check pressures tho. I have been checking through canbus
  11. S

    Vito W639 showing "ESP visit workshop"

    I was driving this week and part way though a journey my van started showing ESP visit workshop of the dash display. I've started to have a look but not gotten anywhere and was wondering if anyone could give me some advice? Van is a 2012 W639 This is the fault and how far I have gotten: Dash...
  12. S

    Best tyres for for a Vito in a field

    I'm planning on using my W639 to tow a caravan to Glastonbury festival next year. The trouble is I've noticed the Vito is absolutely useless on wet grass. Has anyone any experience with fitting chunkier tyres to get over this problem? Ive for a spare set of 16" steel wheels I can fit some tyres...
  13. S

    Vito / /Sprinter gearbox codes

    I've got a 2012 Vito 113 with approx 170k on the clock. Syncro is weak on 2nd gear, changed the oil for ATF-U and the problem still remains. Trying to source a 2nd hand gearbox but I would like to understand what the gearbox codes mean and which ones are compatible. My gearbox is: TSG360VTNVH...
  14. S

    Gearbox codes

    I've got a 2012 113 Vito with the 6 speed manual box, the data card show the gearbox fitted to be a 711680 00 268034 . Am I right in thinking that any 711680 would fit? Is there somewhere that shows what the gearbox codes mean?
Back
Top Bottom