110cdi

Hi all, Just after a bit of advice please, I've got myself a lovely old Vito w638, barely run in with 205k on the clock. The EDC light is permanently on, along with the coil light. It runs absolutely fine, starts first time, blows a little smoke but nothing major and pulls like a train...

Need mechanical help... Vito 110cdi 2003 model. Alternator faults: 1. 4.7amp drain when switched off, chased to alternator 2. Overcharging at 16.7volts when running. 3. No battery light at all, not on ignition, nothing!!! My guess was the regulator was knackered, but now I'm thinking it...

Hi Recently ive had problems with my vito starting. Turns over fine but will not fire for 30 seconds or so. After investigating i found air in the fuel lines and replaced one from the filter to the pump. There is a second hose coming from the fuel pump which appears to disappear towards the...

Can anyone tell me other than the difference in just a few CC what is different in the engines as mine blew up in my vito 111cdi I can't afford another grand as I just bought the van does anyone have any idea or poss a engine knocking around I be very grateful

i have a vito 110 cdi 2003, had a problem with black death and leaking injectors. i have replaced the cylinder head cover / rocker cover and cleaned injectors the retaining bolts were knackered by a previous owners repair so have been re threaded and replaced, i've replaced glow plugs but the...

Hi all, I ve read a few posts regarding some of the issues i have but can't seem to get an answer on one of them. I have a Vito 110CDi 2003 2.2l i have been having a sort of sucking/blowing noise since i had it but always disappeared after a few minutes i put it down to the vac system going...

I have a problem with the revs doesn't exceed more than 3000rpm does anyone know the problem Vito 110cdi w638

I'm after some advice, on looking at my engine bay today i have found a lead with a blue inner plug on it under the plastic housing which is going to nothing. attached pic 1 which goes along and plugs in to another lead shown in pic 2. Should this be attached to something?? Also at back of...

Hello All have a 51 plate Vito when releasing hand brake the light on dash will not go out .I have linked hand brake switch out to no success . When I drive away and speedo registers bleeping starts stops starts stops and continues all intermittently while in motion only time its does not beep...

Hi guys, I am looking to replace my front discs and pads on my vito 110cdi Mk1 - I am wandering which caliper type i need to be purchasing for. From what i have read there are 2 types of caliper for this so not sure which pads i need. Is there a simple way to tell the difference by looking at...

Hello All. Hope someone can help,I purchased the above van knowing it needed a water pump(so i was told) it was a pig ov a job put it back together again filled with water to find it pouring out,ont the back ov the engine above exhaust manifold rhs is where its coming from,is this round hole a...

Only had van about 7 months but been good van! Pretty good on fuel,pulls well :D only thing need do is get cluster done as milage gone which is shame but under 100k not nad for x reg!! Uploaded with ImageShack.us Uploaded with ImageShack.us

I have a Vito 110cdi (2001) which has been a great van apart from rust! The van is fitted with a pre heater which I think burns diesel which heats up the engine when really cold. It has stopped working and now the engine will only get to about 60 deg unless on the motorway and takes an age to...

I have a leak on the egr valve and need to replace the whole valve. I spotted these: EGR Valve for your MERCEDES-BENZ VITO Bus (638) 110 CDI 2.2 (638.194) (102HP) Any idea which one I need and is there a cheaper option? Cheers Mike

Hi there, I'm a newbie on here, & I wonder if anyone on here is able to advise me.? I have recently purchased a 2001 Vito 110cdi with 111k on the clock. It has a "bit of a rattle", and I'm struggling to diagnose it. I've posted up a little video on youtube, http://www.youtube.com/v/TxEgqy-1T54

Wotcha all - located in midlands, got a 2003 638 110CDI, 90K miles had no problems with it so far other than coil light on so need to replace relay, alloy wheels it came with corroded (replaced with OZ's 16's) and it was dropping into safe mode due to the waste gate on the turbo sticking using...

Hi, I have done a quick search of forum but couldnt find any answers to the following question so apologies if this has been answered already elsewhere... Have got a vito 638 110CDI and understand they have the same engine as the 112CDI but dont generate the same power. After some digging I...

Hello All. First post .....long time reader. I am about to purchase a 2001 110cdi dualiner with 108k on the clock. Main reason is we cannont afford a Vclass or a tidy mpv with similer milage but really need a 6 seater with loads of room for camping gear/bikes/ baby junk etc etc. the van is a...

Hello first post since joining and I have a problem. Coming home last night my Vito went into limp mode and I managed to get home. The Vito wont rev over 3000rpm its like hitting a wall or rev limiter at 3000rpm. No engine management light was seen no smoke was observed just loss of power. Any...

Ok i will try and keep this short ... a while ago i purchased this vito 110cdi .. from my mechanic in good faith .. it has had many issues .. but thankfully he has paid for everything so far! ... 1st problem arose .. when i broke down ... failed injector x 1 ... then had van back for a while...