injection

Engine management light came on and I took it local indie and put on star Has thrown up a P2036 fault code which is the secondary air injection system. Tried to have a look round forums for more specific info - on what this may be - but to no avail Can anyone put some flesh on the bones...

Does anyone have any advice they could give me. I have a 2005 SLK350 which has started to throw up a "secondary air injection" alarm (P0410). This only happens when started from cold, if code is reset it does not come back (engine warning light) until the car has been started a couple of time...

My 320TE had one of those smog pumps fitted to the side of the engine, despite it being a RHD UK registered car. It seized earlier this year and I simply took the pump off and bought a shorter belt to fit the remaining pulleys as replacement pumps at the time were really expensive. It sailed...

I have a recurring engine management light fault which keeps appearing, when I check it, it keeps saying that there is a "Secondary Air Injection Malfunction", I clear the fault and its OK then for a few days. I don't seem to be able to narrow it down to any driving style. Anyone know what...

Im looking to sell the LPG kit I bought about a year ago for my 500SEL . The kit came off a 420SEL owned by Mr S on the forum , so all the pipework is the right length for a LWB 126 , although it could be adapted to fit other cars . I should imagine it will fit quite a lot of MB cars from the...

Hi all, A freind and I are trying to gather info on the bosch ke-jetronic injection systems fitted to older mercedes, in paticular we are looking at the size's of the air flow meter plate. So far the only engine we cant find any infomation on is the m119, as fitted to the early 90's sl, and...

Hi I'm really stuck trying to remove the valves from the op of my injection pump to replace the rubber O rings and copper washers. 1992 300D K650EYL Vin. WBD1241902F241396 Engine no. 60391222059433 I have bought the 33pt spline x56mm long socket (laser tools 5471) that is...

Hello gentlemen, Being in the process to lower my fuel consumption, I found out the description below. Assuming the info is real (I do not have access to any other description or technical info about this engine), it appears obvious that this particular engine fuel management wastes half of the...

W124 Water/methanol Injection / ignition live feed Hi all, I run veg oil on my W124 300TD. I have installed my devils own methanol pump and some of the wiring along with the relay. I need a ignition live feed to complete the install. The pump is located in the boot in the place which housed...

As per the title really... If you have a good one please email me on [email protected]

Hi there, I have a Mercedes A140 (02). About 2 days ago i had a problem with my secondary injection air pump Part number: A 000 140 40 85, the motor is continuously on after the engine is turned of, could anyone advise if the motor is faulty or the relay switch? Also we have unplugged the...

I've just had a star diagnostic on my W140 and the only fault code (After chnaging one of the coil packs) was for "secondary air injection - left" . I don't have any warning lights on the dash, or any other indication of a problem. All the other posts I've seen on the subject have been for...

I recently load tested the Varta battery in my W202 C220 CDi. It showed up as ‘weak’ despite being regularly conditioned with a CTEK charger and was only about three and a half years old. I suspect it has a faulty cell. I replaced it. It is no surprise that the car now starts in a more...

Hi, My 2000 Mercedes A140 petrol seems to have started to be a bit nasty on the petrol side (ie. it's eating more than usual), so I thought I'd give it a single treatment of redex. Can anyone tell me which one I need, the Redex Petrol Cleaner or Petrol Injection cleaner? Thanks.

Anyone got a secondary air injection unit (part No 0001404285) for my AMG e55 w211, hoping to buy one second hand, the relay has burnt it out apparently!! Please let me know of any AMG breakers as I don't know any?:thumb:

My 240d engine has done 100k kms in 30 years. The engine seems to be pretty noisy to me. I have done the valve clearances but nothing else. Injectors? Can the injectors be cleaned or only changed? All the filters are done btw. Also, there is a tinkling sound coming from the front of the engine -...

Hello all! My car is still in and out of the local indy specialist- the vacuum pump went and took the ramp gear that drives it with it. All been replaced but now it's got timing issues. The guys have put everything back according to the specs in the Mercedes manuals, for an OM606 engine it's...

My car suffered from the secondary air injection warning light displayed when I first got it so it got fixed under warranty, then a week later it came back, this time all the wires were checked etc, all fuses and relays to do with the pump replaced and a new pump free of charge from the garage...

One of the bits done on my car under warranty last week was the secondary air injection pump, but it looks like it has malfunctioned again less than a week later which I might have a hard time trying to sell to get it fixed under warranty again, I've read some stuff on US forums that there is a...

I was thinking now that a new pump is to be fitted and with full knowledge it will happen again, would it be possible to either take out the fuse, or install an in-line switch, and place it back in/switch it on, when to MOT come along? Or, would the COMMAND just throw up the check engine...